冬天天气寒冷，什么东西都容易上冻，那么这种天气下应当如何保养好混凝土搅拌机呢。搅拌机保养时，底盘护理容易忽略的司机朋友，但在冬季或潮湿的天气的好坏底盘的重要性是显而易见的。

It's cold in winter, everything is easy to freeze, so how to maintain the concrete mixer in this weather. Mixer maintenance, chassis care is easy to ignore the driver friend, but in winter or wet weather the importance of good or bad chassis is obvious.

在冬天要做底盘底盘将会彻底的清洗和防锈处理。首先对底盘进行彻底清洁，如果底盘上太多的污垢，用脱脂洗涤剂洗一遍，使底盘给原来的“本能”，所以防锈护理就可以开始了。在美容院，混凝土泵车可以到吊架底盘清洗、擦拭，然后防锈护理。中间的注意，清洗后必须等到底盘水分干透后，防锈剂保健。照顾，一定要保持喷雾均匀应用涂料，形成一层保持持久的统一的防锈涂料。所有自然干燥后再进行5 - 10分钟完成，为了完成底盘防锈处理。

In winter to do chassis, chassis will be thoroughly cleaned and antirust treatment. First of all, clean the chassis thoroughly. If there is too much dirt on the chassis, wash it with degreasing detergent once to make the chassis give the original "instinct". Therefore, rust prevention care can start. In the beauty salon, the concrete pump truck can go to the hanger chassis to clean, wipe, and then rust protection. In the middle of the attention, after cleaning must wait until the chassis moisture dry, antirust agent health care. Care must be taken to keep the spray evenly applied and form a durable and uniform rust preventive coating. All natural drying after 5 - 10 minutes to complete, in order to complete the chassis antirust treatment.
              

你去做卡护理沙龙，它的质量是好是坏，有一个简单的方法来尝试：底盘防锈护理后的高压水喷不挂水，所以代表的效果是关心，才会有很好的防锈。

If you go to the card care salon, whether its quality is good or bad, there is a simple way to try: the high-pressure water spray after the chassis antirust care does not hang water, so the representative effect is care, and there will be good rust prevention.

当搅拌机在野外或远离搅拌机和会见底盘零部件损坏，针对不同故障情况，可以利用以下急救方法将车车库条件。

When the mixer is in the field or far away from the mixer and meets the chassis parts damage, the following emergency methods can be used to change the garage conditions according to different fault conditions.

刹车制动液泵泄漏或分断泵管，可以在点由于三叉做了一个小垫铁，铜，阻塞管道，然后拧紧螺丝，或夹断口平坦，泄漏，不能使车轮制动器使用。但是这样做可能会造成单边制动，开车时要注意安全。

If the brake fluid pump leaks or breaks off the pump pipe, a small pad iron and copper can be made at the point to block the pipe, and then the screw is tightened, or the fracture surface of the clamp is flat and leaking, so the wheel brake can not be used. However, this may result in unilateral braking. Pay attention to safety when driving.

制动主缸，制动液可以代替酒精或白酒，特殊情况下可以代替水。制动杯膨胀，膨胀的杯热水浸泡10分钟至20分钟，组成的油杯，这样你就可以恢复原始大小的杯子。

Brake master cylinder, brake fluid can replace alcohol or liquor, in special cases can replace water. The brake cup is inflated and the inflated cup is soaked in hot water for 10 to 20 minutes to form an oil cup, so you can restore the original size of the cup.

离合器摩擦片消融滑动、摩擦片烧蚀不太严重，可以用来翻转。如烧蚀严重，可用棉布或帆布层(其厚度应符合原始摩擦盘)，钢丝或铁丝穿过钢片上的孔，使其固定。当驾驶车辆应开始顺利，迅速转移行动。

Clutch friction plate ablation sliding, friction plate ablation is not too serious, can be used to flip. If the ablation is serious, cotton cloth or canvas layer (its thickness should be consistent with the original friction disc) can be used, and steel wire or iron wire can be passed through the hole on the steel plate to make it fixed. When driving a vehicle should begin smoothly, move quickly.

混凝土搅拌机拉杆球接头失败，保险杠或其他不影响开车，卸载一个类似于球关节螺钉的总长度，球形接头的失败，而是转向节臂安装螺母，螺栓显示良好的用锤子铆接。三轴车辆差速齿轮损坏，如后桥差速器损坏，任何一个桥可以驱动轴，驱动轴，继续开车。如果是前者微分损伤，轮毂接合板可以删除。

Concrete mixer pull rod ball joint failure, bumper or other does not affect the start-up, unload a similar to the total length of ball joint screw, spherical joint failure, but steering knuckle arm mounting nut, bolt shows good riveting with hammer. If the differential gear of the three axle vehicle is damaged, if the rear axle differential is damaged, any axle can drive the shaft, drive shaft and continue driving. If the former is differential damage, the hub joint plate can be deleted.