搅拌一体机增压器的作用就是提高发动机进气量，让车辆动力更强劲。但增压器的工作环境对冷却、润滑和动平衡有极高的要求，因此，为了延长增压器的使用寿命，通过以下4个方面来对搅拌一体机增压器进行日常保养：

The function of the supercharger of the integrated mixer is to increase the air intake of the engine and make the vehicle more powerful. However, the working environment of the supercharger has extremely high requirements for cooling, lubrication and dynamic balance. Therefore, in order to extend the service life of the supercharger, the daily maintenance of the supercharger of the mixer is carried out in the following four aspects:

1、冷车时不可着车就走

1. Don't leave when the car is cold

车辆停驶一夜以后，机油因为重力作用会流回到油底壳中，在启动发动机后要怠速运转一分钟左右让机油循环建立，使增压器浮动轴承得到充分的润滑后再起步行驶。

After the vehicle is stopped for one night, the oil will flow back to the oil pan due to gravity. After starting the engine, it is necessary to run at idle speed for about one minute to establish the oil circulation, so that the floating bearing of the supercharger can be fully lubricated before starting.

2、高速运行后不要立即熄火

2. Do not shut down the engine immediately after high-speed operation

增压器在工作的时候转速很高，高速行驶后若是立即熄火，机油供给会突然中断，此时增压器仍在高速旋转，这样浮动轴承内的机油很快会被磨干，浮动轴承就会受到损伤。正确的做法应该是在熄火前怠速运行至少一分钟再熄火。

When the supercharger is working, the speed is very high. If the engine is shut down immediately after driving at high speed, the oil supply will be interrupted suddenly. At this time, the supercharger is still rotating at high speed, so the oil in the floating bearing will be dried quickly and the floating bearing will be damaged. The correct approach should be to run at idle speed for at least one minute before shutting down the engine.

3、机油和滤芯不能马虎

3. The oil and filter element should not be sloppy

增压发动机的运行环境都比较恶劣，所以对机油的要求相对也较高，在选择机油的时候好按照厂家要求的粘度和级别来使用更换。滤芯就更不用说了，必须使用正规厂家的产品，如果使用劣质滤芯，会对增压器的浮动轴承造成损害，严重会导致转子抱死，增压器报废。

The operating environment of supercharged engines is relatively bad, so the requirements for engine oil are relatively high. When selecting engine oil, it is better to use and replace it according to the viscosity and grade required by the manufacturer. Not to mention that the filter element must be the product of a regular manufacturer. If the inferior filter element is used, the floating bearing of the supercharger will be damaged, and the rotor will be locked and the supercharger will be scrapped.

4、空滤也同样重要

4. Air filtration is equally important

空滤是否正常也会关系到增压器，因为增压器轴承腔的密封主要是依靠两边的气压差。很多时候增压器串油都跟这个有关，有时车主换下的串油增压器可能只是次品空滤或者是空滤堵塞造成的。

Whether the air filter is normal will also affect the supercharger, because the sealing of the bearing cavity of the supercharger mainly depends on the air pressure difference on both sides. Many times, the oil spilling of the supercharger is related to this. Sometimes the oil spilling supercharger replaced by the owner may be caused by defective air filter or air filter blockage.

对搅拌一体机增压器进行日常保养的相关内容就到这里了，您对此可以来进行详细看看，希望能够给您帮助！更多关注，来网站http://www.zkhntjbj.com咨询吧！

That's all for the routine maintenance of the supercharger of the mixer. You can have a detailed look at it. I hope I can help you! More attention, come to the website http://www.zkhntjbj.com Consult!