混凝土搅拌机的正确操作规范包含什么内容呢？要想后期更好的使用该设备进行施工，就要多多来了解，下面小编为您讲解。

What is included in the correct operation specification of concrete mixer? If you want to better use this equipment for construction in the later stage, you need to learn more. The following editor will explain it for you.

1.使用前检查:输电前按下开关，然后关闭开关，检查操作是否灵活。振动器、滚筒和拨杆是否正常工作。钢丝绳缠绕在卷筒上；混凝土平台的升降是否正常。如果发现故障，通知机电队处理。处理后才能使用。

1. Inspection before use: press the switch before power transmission, and then close the switch to check whether the operation is flexible. Check whether the vibrator, roller and paddle work normally. The steel wire rope is wound on the drum; Whether the lifting of concrete platform is normal. If any fault is found, notify the mechanical and electrical team to deal with it. It can only be used after processing.

2.一次上料不能过多，按配比上料，注意水灰比。搅拌均匀，一次搅拌时间不得少于一分钟。正常搅拌的混凝土应该是稠粥。

2. One time feeding shall not be too much, feeding shall be carried out according to the proportion, and attention shall be paid to the water cement ratio. Stir evenly, and the mixing time shall not be less than one minute. The normally mixed concrete should be thick porridge.

3.固定专人开机，操作人员应熟悉各操作系统的工作原理，发现故障应立即停机检查。

3. A special person shall be assigned to start the machine. The operator shall be familiar with the working principle of each operating system. In case of any fault, the machine shall be shut down immediately for inspection.

4.电器部件应加以爱护，电缆应加以保护，防止损坏。

4. Electrical components shall be protected, and cables shall be protected to prevent damage.

5.混凝土搅拌机应平整，搅拌机漏斗下不得站人，以免漏斗落石伤人。

5. The concrete mixer shall be flat, and no one shall stand under the hopper of the mixer to avoid injury caused by falling stones.

6.临时停机时，定期(每20分钟)启动搅拌机，防止混凝土凝固或倒出滚筒中的混凝土，用水冲洗滚筒。

6. During temporary shutdown, start the mixer regularly (every 20 minutes) to prevent the concrete from setting or pouring out the concrete in the drum, and wash the drum with water.

7.混凝土浇灌停止后，应及时用水冲洗滚筒和机外的砂浆。进料斗每班清洗一次，使进料斗下放时落到指定位置，外观涂一层油，待下次使用。

7. After the concrete pouring is stopped, the roller and mortar outside the machine shall be washed with water in time. The feed hopper shall be cleaned once every shift to make it fall to the specified position when lowering, and a layer of oil shall be applied on the appearance for the next use.

8.认真实施交接制度，明确说明工作机器的运行和注意事项。

8. Carefully implement the handover system and clearly explain the operation of the working machine and precautions.

注意：次用完后都要及时清洗，否则等混凝土凝固后很难清洗，费时又费力。更多相关注意事项可以来我们网站http://www.zkhntjbj.com咨询。

Note: clean it in time after use, otherwise it will be difficult to clean after the concrete is set, which is time-consuming and laborious. For more relevant precautions, please visit our website http://www.zkhntjbj.com consulting service