自动上料搅拌机运行的使用规范
来源：http://www.zkhntjbj.com/日期：2022-10-03
自动上料搅拌机运行的使用规范是怎样的？这里小编为大家介绍一下有关自动上料搅拌机运行使用规范的一些相关信息。
What are the operation specifications of the automatic feeding mixer? Here, we will introduce some relevant information about the operation and use specifications of the automatic feeding mixer.
1、自动上料搅拌机在运输砼的过程中，搅拌筒不得停止转动，以免混凝土产生离析现象。
1. During the transportation of concrete, the mixing drum of the automatic feeding mixer shall not stop rotating to avoid segregation of concrete.
2、自动上料搅拌机上路行驶时，卸料溜槽降至低处并转至与车身垂直部位，用锁紧装置把卸料溜槽锁紧在机架上，防止由于不固定而摇动，造成伤人事故和影响其它车辆运行。
2. When the automatic feeding mixer is running on the road, the discharge chute is lowered to the lower position and turned to the vertical position with the vehicle body, and the discharge chute is locked on the rack with a locking device to prevent shaking due to unfixed, causing injury accidents and affecting the operation of other vehicles.
3、车辆须严格按照厂家的载质量运营，不能超载。
3. The vehicle must be operated in strict accordance with the manufacturer's load weight and cannot be overloaded.
4、启动水泵开关时，须保证水泵里有水，水泵连续运转时，切勿将水阀关闭。冬季停放时供水系统须排空，并打开所有关闭球阀使水流出。
4. When starting the water pump switch, ensure that there is water in the water pump. Do not close the water valve when the water pump is running continuously. When parking in winter, the water supply system must be drained, and all closed ball valves must be opened to allow water to flow out.
5、对于新购置的自动上料搅拌车，在使用前须对底盘及上装所有涉及到螺钉的地方进行从新加固后方可运营。
5. For the newly purchased automatic feeding mixer, the chassis and all places where screws are involved must be reinforced before use.
6、减速机首次使用工作100小时须更换润滑油，以后每工作1000小时或一年更换一次润滑油（取其中时间短者）。新车首次工作累计满300小时后须更换液压油和液压油滤清器滤芯。
6. The lubricating oil must be replaced after the reducer has been used for 100 hours for the first time, and then every 1000 hours or once a year (whichever is shorter). The hydraulic oil and hydraulic oil filter element must be replaced after the new vehicle has been operated for 300 hours for the first time.
以后每工作1500小时或六个月（取其中时间短者）更换液压油和液压油滤清器滤芯。更换液压油时须先把油箱系统内原来的液压油全部放完后才能加入新的液压油。
Replace the hydraulic oil and hydraulic oil filter element every 1500 hours or six months (whichever is shorter). When replacing the hydraulic oil, drain all the original hydraulic oil in the oil tank system before adding new hydraulic oil.
When the truck is stopped, turn the operating handle to make it in the middle position (even if the mixing drum is in a static state). Non operators are forbidden to operate, and operators need to operate according to the instructions provided by the manufacturer. Come to our website for more information http://www.zkhntjbj.com Consult!
全国服务热线
点击拨打服务热线：400-879-1999
