混凝土搅拌机可以广泛的应用在大型建筑工程中，例如公路、桥梁、水利等，并且是一种效率非常高的设备。今天小编就带大家仔细的了解以下混凝土搅拌机的操作注意事项。

Concrete mixer can be widely used in large construction projects, such as roads, bridges, water conservancy, and is a very efficient equipment. Today, Xiaobian will take you to carefully understand the following precautions for concrete mixer operation.

1、搅拌机周围要用支架支撑，并且将搅拌机放在坚固的地方。

1. The mixer shall be supported by supports around it and placed in a solid place.

2、搅拌机在使用前要先进行检查，确保设备控制器和各部件完好以后才可以正常运行。搅拌机的筒内不能存在异物，否则会影响到后面的搅拌效果。

2. The mixer shall be checked before use to ensure that the equipment controller and components are in good condition before normal operation. There shall be no foreign matters in the barrel of the mixer, otherwise the mixing effect will be affected.

3、搅拌机在进料斗升起的时候，为了安全起见，禁止人员通过或停留在料斗下方；搅拌机在运行时，不能将工具深入到搅拌筒内。

3. When the mixer is raising the feed hopper, for safety reasons, it is forbidden for personnel to pass or stay under the hopper; When the mixer is running, do not put the tools into the mixing drum.

4、如果现场需要维修，需要将搅拌机的料斗固定好，断电以后才可以进行维护。如果要进入到搅拌筒内，外面则需要有人员看管。操作人员须持证上岗，禁止将混凝土机械交给无证人员操作，作业时应集中精力，正确操作，不得擅自离岗。

4. If maintenance is required on site, the hopper of the mixer shall be fixed, and maintenance can only be carried out after the power is cut off. If you want to enter the mixing drum, you need someone to watch outside. The operator must hold a certificate to work. It is forbidden to hand over the concrete machinery to an unlicensed person for operation. During operation, the operator should concentrate on correct operation and not leave the post without authorization.

5、作业前应检查搅拌机的固定、离合器、制动器、滑轮、钢丝绳、传动装置、上料斗限位、电气线路、保护接零或接地线等，如有异常须排除。

5. Before operation, check the fixation, clutch, brake, pulley, wire rope, transmission device, hopper limit, electrical circuit, protective neutral or grounding wire of the mixer, and eliminate any abnormality.

6、升起上料斗后，料斗下方严禁人员进入，清理料斗下方时，须挂上保险链，搅拌桶内有人进入清理和维修作业时，应拉下开关箱内的隔离开关，锁好开关箱，以免误操作伤人。

6. After the hopper is raised, no one is allowed to enter under the hopper. When cleaning the hopper, safety chains must be hung. When someone enters the mixing bucket for cleaning and maintenance, pull down the isolating switch in the switch box and lock the switch box to avoid injury caused by misuse.

作业完毕，应将机械清理干净，切断电源，锁好开关箱。安全很重要，所以您在使用该设备进行施工时就要多注意了，更多相关内容就来我们网站http://www.zkhntjbj.com咨询吧！

After the operation, the machinery shall be cleaned, the power shall be cut off, and the switch box shall be locked. Safety is very important, so you should pay more attention when using this equipment for construction, and more relevant content will come to our website http://www.zkhntjbj.com Consult!