混凝土搅拌机的操作与运用
来源：http://www.zkhntjbj.com/日期：2022-07-15
搅拌机的操作与运用有哪些注意事项？在运用搅拌机的时候要注意什么？今日我们的技术人员为大家谈谈搅拌机的操作与运用。
What are the precautions for the operation and application of the mixer? What should we pay attention to when using the mixer? Today, our technicians will talk about the operation and application of mixer.
运用前查看：
Check before use:
查看机器运转是否稳定，支腿是否结实支撑，爬梯支腿垫实状况。
Check whether the machine operates stably, whether the outriggers are firmly supported, and whether the ladder outriggers are padded.
机器空转正常。
The machine idles normally.
起动水泵，试泵正常供水。
Start the water pump and test the normal water supply of the pump.
电气接地杰出。
Excellent electrical grounding.
操作注意事项
Precautions for operation
加入拌和物料不得超过其规则的数值。必须等拌和筒内出料完毕后方能提高上料。
The addition of mixed materials shall not exceed its regular value. Loading can be increased only after the discharge in the mixing drum is completed.
实斗不行随意下放，遇特殊状况时，需带刹车做平稳缓慢下降。
The solid bucket cannot be lowered at will. In case of special conditions, it is necessary to bring the brake to make a steady and slow descent.
为减少粘料现象，料斗加骨料次序应当为：石子>水泥>砂，或许砂>水泥>石子
In order to reduce the phenomenon of sticking, the order of adding aggregate in the hopper should be: Stone > cement > sand, perhaps Sand > cement > stone
上料中要及时加水，减少拌和时间与灰尘的分布。
Add water in time to reduce mixing time and dust distribution.
提高料斗时，禁止任何人在斗下停留。空料斗下放时须缓慢，以增加部件的运用寿命。
When raising the hopper, no one is allowed to stay under the hopper. Empty hopper must be lowered slowly to increase the service life of components.
操纵杆手柄禁止随意扳动。
It is forbidden to pull the joystick handle at will.
注意电气，避免电机受潮大型混凝土搅拌机，避免电气元件、电线遭到损坏。
Pay attention to electrical safety, avoid the motor from being damp, large concrete mixer, and avoid the damage of electrical components and wires.
停电时，用曲柄摇杆来减速箱皮带盘，可将罐内的物料排出。
In case of power failure, the material in the tank can be discharged by using the crank rocker to reduce the gearbox pulley.
运用后的保养
Maintenance after use
停机前放入少量石子和水，拌和3-5分钟后放出，重复数次以铲除筒内的积物。每班工作完毕须将筒内积物铲除洁净。
Before stopping the machine, put a small amount of stones and water, mix them for 3-5 minutes, and then release them. Repeat several times to remove the deposits in the barrel. After the completion of each shift, the accumulation in the cylinder must be removed and cleaned.
清洗积灰与全机所粘大型混凝土搅拌机附的混凝土。
Clean the accumulated ash and the concrete attached to the large concrete mixer attached to the whole machine.
将料斗安顿在运输方位上挂好保险挂钩。
Place the hopper on the transportation position and hang the safety hook.
切断电源，锁好电气箱。
Cut off the power and lock the electrical box.
冰冻季节应将供水系统内各处剩水排出。
During the freezing season, the remaining water in the water supply system should be discharged.
酌情对各润滑点加注必要的润滑油。
Add necessary lubricating oil to each lubricating point as appropriate.
拖行时注意事项：
Precautions when dragging:
查看行大型
混凝土搅拌机走系统的紧固件是否松动，而且用铁丝将滚筒和底盘固定。
Check whether the fasteners of the walking system of the large concrete mixer are loose, and fix the drum and chassis with iron wire.
拖行速度不大于每小时20。
The towing speed is no more than 20 kilometers per hour.
The above is all about the problems and precautions introduced to you today. I hope it can help you. If you want to know more, you can contact us by phone or follow our website, and our staff will contact you in time.
全国服务热线
点击拨打服务热线：400-879-1999
